Face to Face with Ben Rodrigues: Ordinary Mechanic with Extraordinary talent

April 5, 2010

Meet the man who has a technology that is environmental friendly as Arron Menezes finds out:

Two friends in a car travelling to a hill station… the petrol tank is in the reserve mode. They cross the petrol bunk and reach the hill station. One friend asks the other ‘Kya dalte ho gaadi mein??? (what do you put as fuel?)

The days are not far when we would be witnessing such advertisements in local and then on National TV Channels. You may have guessed it by now that it is something related to fuel. With fuel prices rocketing high like anything, everyone is thinking ‘what next???’

Well, there surely is not an immediate answer to this question but if we all could do something, I think we should be able to find one. I said ‘we’. You heard it right, didn’t you? If I say there is a Mangalorean coming up with a solution to fuel and environment problems, I doubt that you might think I have gone crazy or maybe I’m trying to fool you as April is underway.

The name is Ben. Ben Rodrigues. The 73 year old, a common automobile engineer with extra ordinary capacity, has the answers for our ‘what next?’ question.

This system is simple - a device installed on exhaust manifold of engine which receives the exhaust to the water content in that and filters the carbon, unburnt fuel molecules and heat of the exhaust and recycles through the inlet manifold in the form of water moisture.

The water moisture consists of hydrogen and oxygen. In the act of compression and combustion the water splits into Hydrogen and Oxygen. Further supports to increase combustion efficiency power and decrease the heat of exhaust and fuel consumption in a very great quantum. The system works as catallic converter and fuel conserving unit. However the reduction of heat from the exhaust gases is main objective of this project.

In conventional Petrol and Diesel the exhaust carries 20 to 40 percent of carbon and in the fuel it is 80 percent and 15 percent of hydrogen. It ends in burning 50 to 60 percent leaving 50 percent of green house gases and 60 to 70 percent of heat in the environment.

In this system as mentioned earlier due to hydrogen the Petrol and Diesel burns out completely resulting in greater mileage and reduction of heat. Approximately 5 to 10 percent of heat will be emitted making the fuel efficiency increase from 25 to 100 percent. The conventional vehicles emit heat but this technology uses heat.

In the form of compression and combustion when the heat increases, more than 700 % of water molecules are split into hydrogen and oxygen same as in conventional vehicle as Petrol, Diesel and Inflammable Gas in combustion process. Added hydrogen supports the combustion efficiency and reduces fuel consumption further reducing exhaust heat and carbon drastically.

Now you may be thinking where is this guy from? Where was he hiding till now?

Ben Rodrigues, is ardent fan of Mr Bosch, owner of Bosch German Leading Automobile Company. He is a married man and has 3 daughters, 2 of them married and settled in Mangalore, and one working in Bangalore in a Bank.

He started his career working in an automobile industry in 1953. He got his basic apprenticeship from Canara Workshop Limited Mangalore. Soon he went to Bombay and joined BEST. He then joined the Indian Army under EEM i.e. training from Foreign engineers and providing training to army engineers of India as Civilian trainee.

In 1962during the Sino-Indian war, he was trapped in Missamari, Assam, where he lost all his belongings including his Nissan van and all his tools. He had to escape from the Chinese forces upto Rangia to catch an open goods train to Allahabad Indian Army Headquarters. After reaching the Headquarters he resigned from the office.

Later, he went back to Assam and joined Telco Service. He organized a dealer point in Tejpur and Assam. Then he also organized a Mico Service Center in Tejpur.

In 1967 he returned to Mangalore and joined Aravind Motors as their Work Manager. Aravind Motors were then the dealers for Tata and Mahindra & Mahindra Tractors for Mangalore and Shimoga. During that time he got an exposure in Mechanised Farming.

By 1970 he had started his own farm equipment services at Shimoga, which is still running under the name of Rodrigues Tractor Service, owned and managed by his nephew Staney Rodrigues.

In 1972 he came down to Mangalore and started his own Diesel Fuel Injection Service center at Balmatta, Mangalore. In 1975 he proposed the Government of India about the need for a technology to conserve fuel and reducing the pollution from automobile exhaust.

In response, Mr T A Pai, the then Union Minister, introduced him to Dr P C Alexander, Industrial Development Commissioner in Government of India. Dr P C Alexander called a symposium and during the discussion he found Ben’s suggestions very important for Indian automobile economy and ecology. He issued a letter of appreciation and gave permission to import necessary components and assemble the equipment to test engines for pollution control and fuel economy and market in India.

Ben developed a project as per his proposal. After receiving the letter, he acquired a land of 1 acre in Baikampady Industrial Area and built a factory. He then visited Germany and Austria as per the recommendation of the Government of India. There, he signed a MOU with a German firm for manufacturing Hydro Static Transmissions for installation in conventional automobiles for reduction of fuel consumption which is now introduced by Electric Drive in Hybrid automobiles example Honda hybrid but present system of electric motor Hybrid system cannot be installed in old conventional gear vehicle.

His project was not shelved. In order to cut down the fuel consumption, he developed a new technology which can be altered in conventional vehicles.

Between this from 1975 to 2004 he spent a huge amount, around 75 Lakhs, paying KSFC (Karnataka State Finance Corporation) and SBI (State Bank of India) as interest and Capital return. He broke financially as a result and had to sell his 1 acre land for 25 Lakhs rupees and pay off everything to KSFC and SBI. He quit from Baikampady area stations in Padil, Kannur, areas with his old machinery, tools and books.

In 1994 after paying the entire loan he started his work again in his present station where he developed Hydro Static Transmission for conventional vehicles. It was his original idea of conserving fuel of automobiles and reducing atmospheric pollution caused by incomplete combustion of automotive engines.

When I interviewed him I remembered a message saying smooth roads never make a good rider. Well, his road was a tough one, which only he could travel.

Presently he has RBF Diesel (Rodrigues Ben Franchise), a small workshop with tools in it, near Padil Kannur. With a Mercedes Benz car assembled completely from junkyard for 35,000. He has spent nearly two lakh rupees on for the vehicle which runs on his innovative technology. He gives a demonstration to people interested. He will change any vehicle to his technology but he needs patent. He can’t do that either.

If the government agrees on to support this project India can conserve million tones of Hydro carbon fuel and can reduce pollution in the atmosphere within next 10 years.

He faces the following hurdles in making his technology available to the public:

  1. It has to be patented in his name.
  2. Tested in All India Research Institute Pune

It has to certify the system which means he would have to shell out Rs. 6 Lakh.

  1. Rs. 10 Lakhs for testing the equipment.
  2. Establishing of a workshop for the district as a district center that would cost Rs. 2 Crore.
  3. Creating awareness among vehicle owners
  4. Training to ordinary technicians.
  5. Establishing franchise with other technicians.
  6. Collaboration with government, automobile industries and educational institutions.

There are certain other obstacles too. If the fuel consumption reduces, then obviously the revenue will be less to the government. New automobile companies will not implement his technology because if it makes its way in to the market, they will be at loss.

Personally he has not got much help. He now leads a poor life. It is the spirit of doing good to the nature and humans that still makes him dream of seeing his technology being implemented one day. Belonging to a generation of fast forwardness I think we have to learn a lot from this personality, especially his patience and perseverance.

While on road back to office I remembered something he had mentioned while he was in Germany, Germans had provided all the facilities to make him stay back there. But he was firm with his decision that he will do it in Mangalore. One of the Germans had told him that he will never succeed there. Mr Ben just smiled and returned.

I wish we would prove the German wrong….

benrodrigus_1

benrodrigus_2

benrodrigus_3

benrodrigus_4

benrodrigus_5

benrodrigus_6

benrodrigus_7

benrodrigus_8

benrodrigus_9

benrodrigus_10

benrodrigus_11

benrodrigus_12

benrodrigus_13

benrodrigus_14

benrodrigus_15

benrodrigus_16

benrodrigus_17

benrodrigus_18

benrodrigus_19

benrodrigus_20

benrodrigus_21

benrodrigus_22

benrodrigus_23

benrodrigus_24

benrodrigus_25

Comments

Add new comment

  • Coastaldigest.com reserves the right to delete or block any comments.
  • Coastaldigset.com is not responsible for its readers’ comments.
  • Comments that are abusive, incendiary or irrelevant are strictly prohibited.
  • Please use a genuine email ID and provide your name to avoid reject.
Ram Puniyani
January 26,2020

During last couple of decades we have been witnessing the coming up of various statues in different parts of the country. There is diverse political logic and different set of political tendencies for erecting these statues. When Mayawati was UP CM, she got multiple of her own statues made, in addition to many statues of major dalit icons, irrespective of the criticism against that act. As per her strategy it was a symbol of identity of dalit assertion. The biggest statue to come up was that of Sardar Vallabh Bhai Patel, a lifelong Congressman, whom RSS combine is trying to appropriate. This statue of Unity was ‘Made in China’. The clever trick was that the same forces were behind this statue, which was banned by Patel in the aftermath of Gandhi murder. Interestingly while currently BJP is blaming Congress for Partition of India, ironically it was Sardar Patel who was in the committee which gave final stamp of approval for the partition of India.

There is also a talk in UP, where the Ram temple campaign yielded rich electoral dividends for BJP, to have tallest statue of Lord Ram in Ayodhya. In a state where children are dying in hospitals due to lack of Oxygen cylinders, a huge budgetary allocation will be required for such project. While on statues one should also remember that in Maharashtra a tall statue of Chatrapati Shivaji Maharaj is underway in Arabian Sea, near Mumbai. Only few voices of protest against it came up, e.g. that of renowned journalist, now, MP, Kumar Ketkar, whose house was vandalised for his opposing the move on the grounds that same massive amount can be utilized for welfare-development activities in the state.

On the back of this comes a comparatively low budget 114 feet tall statue of Jesus Christ in Karnataka, in Kappala hills Harobele village, where Christian pilgrims have been thronging from last several centuries. The land for this has been donated by Congress leader Shivaprasad and his brother, a Congress MP. It is planned to be carved out from a single rock. The plan of this statue is being opposed by those who have been behind most of the statue projects so far. Hindu Jagran Vedike, VHP, RSS are up in arms saying that they will not let this come up. There are various arguments cited for this opposition. It is being said that this was a place of worship of Lord Munnieshwara (a form of Lord Shiva).

More than this it is being argued that Shivakumar is trying to please his Italian boss in the party. Also that this will bring back the period of slavery of foreign rule, the colonial rule of British. As such this opposition is more in tune with the ideology of RSS combine, which has been for a statue here and a statue there. Their politics regards Christianity as a ‘foreign religion’! It is true that in Citizenship Amendment Act, they have not excluded Christianity while other religion, which they regard as ‘Foreign’ i.e. Islam. Here they are using a different logic, that the countries from where persecuted minorities are coming, are Muslim countries, Pakistan, Afghanistan and Bangla Desh.

In India the major targeting by RSS combine has been against Muslims, but Christians are also not spared. Starting in the decade of 1980, an intense propaganda has been going on that Christian Missionaries are converting. As RSS affiliate Vanvasi Kalyan Ashram became active in Adivasi areas, the likes of Swami Aseemanand, Swami Laxmanand and followers of Aasaram bapu spread out in Tribal areas. They started their programs to popularise Shabri and Hanuman, with congregations like Shabri Kumbh being regularly organized in these areas. The aim was to Hinduize the people in those areas.

The first major anti Christian violence came up in the ghastly form of burning alive of Pastor Graham Steward Stains along with his two minor sons Timothy and Philip. RSS affiliate Bajrang Dal's Dara Siingh aka Rajendra Pal was behind this and he is serving the life term for that. At the same time Wadhva Commission was appointed to investigate this crime which shook the country and President K.R. Narayan termed it as the one belonging to the inventory of the black deeds of human history.

The Wadhva commission report pointed out that there was no statistical significant change in the region where the pastor was working. Similarly the national figures tell us that the Christian population, if at all, has marginally declined in last five decades as per the census figures. They stand like this, percentage of Christians in population, 1971-2.60, 1981- 2.44, 1991-2.34, 2001-2.30 and 2011-2.30. There are arguments that some people are converting to Christianity but are not revealing their religion. This may be true in case of miniscule percentage of dalits, who may not reveal there conversion, as they stand to loose reservation provisions if they convert.

The anti Christian violence is scattered and is below the radar most of the places. There was massive valence in Kandhamal, Orissa, when on the pretext that Christians have murdered Swami Laxmananand, a massive violence was unleashed in 2008. On regular basis prayer meetings of Christians are attacked on the pretext that these are attempts at conversion. While there is a huge demand for the schools and colleges run by Christian groups, in Adivasis areas and remote areas the work of Swamis is on.

Now the trend is to dump Christian traditions. Since Ramnath Kovind became President, the usual practice of Carol Singers visiting Rashtrapati Bhavan has been stopped. In the army retreat so far ‘Abide with me’ by Scottish poet, Henri Francis Lyte, a Christian song, a favourite of Gandhi, has been dropped. The Christian minorities have perceived the threat in various forms. Currently they are as much part of the protests against CAA, NPR and NRIC as any other community.

While statues and identity issues cannot have primacy over the social development issues, it cannot be selective. To oppose Jesus Christ statue while spending fortunes for other statues is a part of the agenda of RSS combine, which is unfolding itself in various forms. opposition to Jesus Christ statue being yet another step in the direction.

Comments

Add new comment

  • Coastaldigest.com reserves the right to delete or block any comments.
  • Coastaldigset.com is not responsible for its readers’ comments.
  • Comments that are abusive, incendiary or irrelevant are strictly prohibited.
  • Please use a genuine email ID and provide your name to avoid reject.
Ram Puniyani
June 29,2020

In Minneapolis, US an African American, George Floyd lost his life as the white policeman, Derek Chauvin, caught hold of him and put his knee on his neck. This is a technique developed by Israel police. For nine long minutes the knee of the while policeman was on the neck of George, who kept shouting, I can’t breathe.

Following this gruesome murder America erupted with protests, ‘Black lives matter’. The protestors were not just African Americans but also a large section of whites. Within US one police Chief apologized for the act of this. In a touching gesture of apology the police force came on its knees. This had reverberations in different parts of the World.

The act was the outcome of the remnants of the racial hatred against blacks by the whites. It is the hatred and the perceptions which are the roots of such acts of violence. What was also touching that the state of democracy in US is so deep that even the police apologized, the nation, whites and blacks, stood up as a sensitive collective against this violence.

US is not the only country where the brutal acts of violence torment the marginalized sections of society. In India there is a list of dalits, minorities and adivasis who are regularly subjected to such acts. But the reaction is very different. We have witnessed the case of Tabrez Ansari, who was tied to the pole by the mob and beaten ruthlessly. When he was taken to police station, police took enough time to take him to hospital and Tabrez died.

Mohsin Sheikh, a Pune techie was murdered by Hindu Rashtra Sena mob, the day Modi came to power in 2014. Afrazul was killed by Shambhulal Regar, videotaped the act released on social media. Regar believed that Muslims are indulging in love Jihad, so deserve such a fate. Mohammad Akhlaq is one among many names who were mob lynched on the issue of beef cow. The list can fill pages after pages.

Recently a young dalit boy was shot dead for the crime of entering a temple. In Una four dalits were stripped above waste and beaten mercilessly. Commenting on this act the Union Minister Ramvilas Paswan commented that it is a minor incident. Again the list of atrocities against dalits is long enough. The question is what Paswan is saying is the typical response to such gruesome murders and tortures. In US loss of one black life, created the democratic and humane response. In India there is a general silence in response to these atrocities. Some times after a good lapse of time, the Prime Minister will utter, ‘Mother Bharati has lost a son’. Most of the time victim is blamed. Some social groups raise their voice in some fora but by and large the deafening silence from the country is the norm.

India is regarded as the largest democracy. Democracy is the rule of law, and the ground on which the injustices are opposed. In America though the present President is insensitive person, but its institutions and processes of democratic articulations are strong. The institutions have deepened their roots and though prejudices may be guiding the actions of some of the officers like the killer of George, there are also police officers who can tell their President to shut up if he has nothing meaningful to say on the issue. The prejudices against Blacks may be prevalent and deep in character, still there are large average sections of society, who on the principles of ‘Black lives matter’. There are large sections of vocal population who can protest the violation of basic norms of democracy and humanism.

In India by contrast there are multiple reasons as to why the lives of Tabrez Ansari, Mohammad Akhlaq, Una dalit victims and their likes don’t matter. Though we claim that we are a democracy, insensitivity to injustices is on the rise. The strong propaganda against the people from margins has become so vicious during last few decades that any violence against them has become sort of a new normal. The large populace, though disturbed by such brutalities, is also fed the strong dose of biases against the victims. The communal forces have a great command over effective section of media and large section of social media, which generates Hate against these disadvantaged groups, thereby the response is muted, if at all.

As such also the process of deepening of our democracy has been weak. Democracy is a dynamic process; it’s not a fixed entity. Decades ago workers and dalits could protest for their rights. Now even if peasants make strong protests, dominant media presents it as blocking of traffic! How the roots of democracy are eroded and are visible in the form where the criticism of the ruling dispensation is labelled as anti National..

Our institutions have been eroded over a period of time, and these institutions coming to the rescue of the marginalized sections have been now become unthinkable. The outreach of communal, divisive ideology, the ideology which looks down on minorities, dalits and Adivasis has risen by leaps and bounds.

The democracy in India is gradually being turned in to a hollow shell, the rule of law being converted in to rule of an ideology, which does not have faith in Indian Constitution, which looks down upon pluralism and diversity of this country, which is more concerned for the privileges of the upper caste, rich and affluent. The crux of the matter is the weak nature of democracy, which was on way to become strong, but from decades of 1980s, as emotive issues took over, the strength of democracy started dwindling, and that’s when the murders of the types of George Floyd, become passé. One does complement the deeper roots of American democracy and its ability to protect the democratic institutions, which is not the case in India, where protests of the type, which were witnessed after George Floyd’s murder may be unthinkable, at least in the present times. 

Comments

Add new comment

  • Coastaldigest.com reserves the right to delete or block any comments.
  • Coastaldigset.com is not responsible for its readers’ comments.
  • Comments that are abusive, incendiary or irrelevant are strictly prohibited.
  • Please use a genuine email ID and provide your name to avoid reject.
Ram Puniyani
January 14,2020

In the beginning of January 2020 two very disturbing events were reported from Pakistan. One was the attack on Nankana Sahib, the holy shrine where Sant Guru Nanak was born. While one report said that the place has been desecrated, the other stated that it was a fight between two Muslim groups. Prime Minister of Pakistan Imran Khan condemned the incident and the main accused Imran Chisti was arrested. The matter related to abduction and conversion of a Sikh girl Jagjit Kaur, daughter of Pathi (One who reads Holy Guru Granth Sahib in Gurudwara) of the Gurudwara. In another incident one Sikh youth Ravinder Singh, who was out on shopping for his marriage, was shot dead in Peshawar.

While these condemnable attacks took place on the Sikh minority in Pakistan, BJP was quick enough to jump to state that it is events like this which justify the Citizenship Amendment Act (CAA). Incidentally CAA is the Act which is discriminatory and relates to citizenship with Religion, which is not as per the norms of Indian constitution. There are constant debates and propaganda that population of Hindus has come down drastically in Pakistan and Bangla Desh. Amit Shah, the Home minister stated that in Pakistan the population of Hindus has come down from 23% at the time of partition to 3.7% at present. And in Bangla Desh it has come down from 22% to present 8%.

While not denying the fact that the religious minorities are getting a rough deal in both these countries, the figures which are presented are totally off the mark. These figures don’t take into consideration the painful migrations, which took place at the time of partition and formation of Bangla Desh later. Pakistan census figures tell a different tale. Their first census was held in 1951. As per this census the overall percentage of Non Muslim in Pakistan (East and West together) was 14.2%, of this in West Pakistan (Now Pakistan) it was 3.44 and in Eat Pakistan it was 23.2. In the census held in Pakistan 1998 it became 3.72%. As far as Bangla Desh is concerned the share of Non Muslims has gone down from 23.2 (1951) to 9.6% in 2011.

The largest minority of Pakistan is Ahmadis, (https://minorityrights.org/country/pakistan/) who are close to 4 Million and are not recognised as Muslims in Pakistan. In Bangla Desh the major migrations of Hindus from Bangla Desh took place in the backdrop of Pakistan army’s atrocities in the then East Pakistan.

As far as UN data on refugees in India it went up by 17% between 2016-2019 and largest numbers were from Tibet and Sri Lanka.  (https://www.un.org/en/development/desa/population/migration/publication…)

The state of minorities is in a way the index of strength of democracy. Most South Asian Countries have not been able to sustain democratic values properly. In Pakistan, the Republic began with Jinnah’s classic speech where secularism was to be central credo of Pakistan. This 11th August speech was in a way what the state policy should be, as per which people of all faiths are free to practice their religion. Soon enough the logic of ‘Two Nation theory” and formation of Pakistan, a separate state for Muslim took over. Army stepped in and dictatorship was to reign there intermittently. Democratic elements were suppressed and the worst came when Zia Ul Haq Islamized the state in collusion with Maulanas. The army was already a strong presence in Pakistan. The popular formulation for Pakistan was that it is ruled by three A’s, Army, America and Allah (Mullah).

Bangla Desh had a different trajectory. Its very formation was a nail in the coffin of ‘two nation theory’; that religion can be the basis of a state. Bangla Desh did begin as a secular republic but communal forces and secular forces kept struggling for their dominance and in 1988 it also became Islamic republic. At another level Myanmar, in the grip of military dictatorship, with democratic elements trying to retain their presence is also seeing a hard battle. Democracy or not, the army and Sanghas (Buddhist Sang has) are strong, in Myanmar as well. The most visible result is persecution of Rohingya Muslims.

Similar phenomenon is dominating in Sri Lanka also where Budhhist Sanghas and army have strong say in the political affairs, irrespective of which Government is ruling. Muslim and Christian minorities are a big victim there, while Tamils (Hindus, Christians etc.) suffered the biggest damage as ethnic and religious minorities. India had the best prospect of democracy, pluralism and secularism flourishing here. The secular constitution, the outcome of India’s freedom struggle, the leadership of Gandhi and Nehru did ensure the rooting of democracy and secularism in a strong way.

India so far had best democratic credentials amongst all the south Asian countries. Despite that though the population of minorities rose mainly due to poverty and illiteracy, their overall marginalisation was order of the day, it went on worsening with the rise of communal forces, with communal forces resorting to identity issues, and indulging in propaganda against minorities.

While other South Asian countries should had followed India to focus more on infrastructure and political culture of liberalism, today India is following the footsteps of Pakistan. The retrograde march of India is most visible in the issues which have dominated the political space during last few years. Issues like Ram Temple, Ghar Wapasi, Love Jihad, Beef-Cow are now finding their peak in CAA.

India’s reversal towards a polity with religion’s identity dominating the political scene was nicely presented by the late Pakistani poetess Fahmida Riaz in her poem, Tum bhi Hum Jaise Nikle (You also turned out to be like us). While trying to resist communal forces has been an arduous task, it is becoming more difficult by the day. This phenomenon has been variously called, Fundamentalism, Communalism or religious nationalism among others. Surely it has nothing to do with the religion as practiced by the great Saint and Sufi traditions of India; it resorts mainly to political mobilization by using religion as a tool.

Comments

Ashi
 - 
Tuesday, 14 Jan 2020

If Malaysia implement similar NRC/CAA, India and China are the loser.

Add new comment

  • Coastaldigest.com reserves the right to delete or block any comments.
  • Coastaldigset.com is not responsible for its readers’ comments.
  • Comments that are abusive, incendiary or irrelevant are strictly prohibited.
  • Please use a genuine email ID and provide your name to avoid reject.